West Fraser lumber. File photo.

West Fraser lumber. File photo.

Worker buried in sawdust in a shavings bin at West Fraser B.C. Sawmill

WorksafeBC said rescue was needed on one occasion as the worker was unable to help themself

A worker at the Chasm Sawmill division of West Fraser was buried to about head or chest depth in a wood shavings bin area and needed to be rescued, according to a WorkSafeBC report.

“A worker performing clean up during maintenance type work inside a bin approximately 50 to 80 feet high, 30 feet wide, was engulfed by sawdust and/or wood shavings type recovery waste product,” according to the report. “The need for rescue did arise and the lone worker was engulfed and unable to self-rescue.”

The incident was not immediately reported to the board and between the time of the worker being buried and the conclusion of the full investigation, work resumed.

“This employer did not immediately undertake a preliminary investigation that identified all the unsafe conditions, acts or procedures as far as possible, in order to ensure that work can be continued or resumed,” according to the report. “Also, according to information provided by the employer, another worker was engulfed; however, that worker managed to self-rescue.”

The report notes that West Fraser failed to ensure adequate protection from entrapment or engulfment, a serious health and/or safety hazard.

The worker who entered the wood shavings recovery type bin, “was not provided with and did not wear a lifeline and harness, and was not continuously tended by a standby person who is equipped for and capable of effecting immediate rescue.”

WorkSafeBC was notified approximately one week later during a routine inspection, according to the report.

“This employer failed to ensure the scene of an accident that is reportable under subsection (1) was not disturbed, to permit investigate, and prevent potential injuries or death, and any other worker(s) being engulfed.”

A preliminary investigation report was completed and provided to a WorkSafeBC officer. West Fraser has since developed and performed a risk assessment, developed a safe work procedure for entering the shavings bin and as of Nov. 21 planned an emergency drill for confined space and/or enclosed space within the next 30 days.

Part of the actions includes no entry into the bin unless the material is four feet or less.

“A Vac truck and hose system will be used from outside the bin when materials are greater than four feet.”

The 100 Mile Free Press has contacted West Fraser but has not yet received a response.


newsroom@100milefreepress.net

Like us on Facebook and follow us on Twitter.

Get local stories you won't find anywhere else right to your inbox.
Sign up here

Just Posted

Pitt Meadows resident and photographer Greg Unger marvelled at the beauty of nature during a recent trip to Pitt Lake where he had the “pleasure of meeting up with the local osprey.” Sharing this picture of his new fine-feathered friends, he added: “What a beautiful couple!” (Special to The News)
SHARE: Can you not do that – I have a headache

Send us your photo showing how you view Maple Ridge or Pitt Meadows, and it could be featured soon.

A colourful early morning sky, wispy cloud cover, the Golden Ears Bridge in the background, and the Fraser River and wharf in the foreground demonstrate just some of the breathtaking natural and man-made sights visible from the shoreline in Pitt Meadows – as seen through lens of Pitt Meadows resident Karen Foster. (Special to The News)
SHARE: Wharf offers riverside perspective of the bridge

Send us your photo showing how you view Maple Ridge or Pitt Meadows, and it could be featured soon.

Jim Jensen recently took a leisurely and peaceful paddle on Alouette Lake, in Maple Ridge’s Golden Ears Provincial Park, and marvelled at the beauty of nature. (Special to The News)
SHARE: Floating on the still waters of the Alouette

Send us your photo showing how you view Maple Ridge or Pitt Meadows, and it could be featured soon.

Hayden McGillvray shared a picture taken from the Port Haney train station, looking up the Fraser River from the historic wharf. (Special to The News)
SHARE: Sunset as seen from the train station

Send us your photo showing how you view Maple Ridge or Pitt Meadows, and it could be featured soon.

Silver Valley resident Freda du Plessis was photographing bumblebees near Pitt Lake when a “majestic” osprey flew overhead hunting for food. It snagged this fish, and set down on a pole near du Plessis to eat. (Special to The News)
SHARE: Time to feast

Send us your photo showing how you view Maple Ridge or Pitt Meadows, and it could be featured soon.

Vancouver resident Beryl Pye was witness to a “concerning,” spontaneous dance party that spread throughout social groups at Kitsilano Beach on April 16. (Screen grab/Beryl Pye)
VIDEO: Dance party erupts at Vancouver’s Kitsilano Beach to the dismay of onlookers

‘It was a complete disregard for current COVID-19 public health orders,’ says Vancouver resident Beryl Pye

Deputy Prime Minister and Minister of Finance Chrystia Freeland responds to a question during Question Period in the House of Commons Tuesday December 8, 2020 in Ottawa. The stage is set for arguably the most important federal budget in recent memory, as the Liberal government prepares to unveil its plan for Canada’s post-pandemic recovery even as a third wave of COVID-19 rages across the country. THE CANADIAN PRESS/Adrian Wyld
Election reticence expected to temper political battle over federal budget

Opposition parties have laid out their own demands in the weeks leading up to the budget

Chilliwack Search and Rescue volunteers say that a call on April 17 on Vedder Mountain was affected by bikers who rode through the rescue site, throwing rocks onto members and the patient. (Chilliwack Search and Rescue image)
Chilliwack Search and Rescue team, and patient, sprayed with rocks and dirt during rescue

Volunteer crew speaks out after riders on Vedder Mountain show no courtesy at accident scene

Cannabis bought in British Columbia (Ashley Wadhwani/Black Press Media)
Is it time to start thinking about greener ways to package cannabis?

Packaging suppliers are still figuring eco-friendly and affordable packaging options that fit the mandates of Cannabis Regulations

File photo. THE CANADIAN PRESS/Graeme Roy
One man dead after shooting in Downtown Vancouver

This is Vancouver’s fifth homicide of the year

A syringe is loaded with COVID-19 vaccine at a vaccination clinic run by Vancouver Coastal Health, in Richmond, B.C., Saturday, April 10, 2021. THE CANADIAN PRESS/Jonathan Hayward
B.C. to open up COVID vaccine registration to all B.C. residents 18+ in April

Registration does not equate to being able to book an appointment

(Black Press file photo).
UPDATED: Multiple stabbings at Vancouver Island bush party

Three youths hospitalized after an assault in Comox

Selina Robinson is shown in Coquitlam, B.C., on Friday November 17, 2017. British Columbia’s finance minister says her professional training as a family therapist helped her develop the New Democrat government’s first budget during the COVID-19 pandemic, which she will table Tuesday. THE CANADIAN PRESS/Darryl Dyck
B.C. finance minister to table historic pandemic-challenged deficit budget

Budget aims to take care of people during pandemic while preparing for post-COVID-19 recovery, Robinson said

Most Read